8849
卡特330C挖掘机故障代码中英对照表
2018/8/11
Engine Control发动机控制器(MID No.036)挖掘机维修,挖掘机修理,维修挖掘机,修理挖掘机|CIDComponent元件
0001 Injector Solenoid 1st Cylinder1#缸喷油器电磁阀
0002 Injector Solenoid 2nd Cylinder2#缸喷油器电磁阀
0003 Injector Solenoid 3rd Cylinder3#缸喷油器电磁阀
0004 Injector Solenoid 4th Cylinder4#缸喷油器电磁阀
0005 Injector Solenoid 5th Cylinder5#缸喷油器电磁阀
0006 Injector Solenoid 6th Cylinder6#缸喷油器电磁阀
0041 8V DC Supply 8V直流电源
0042 Injection Actuation Control Valve喷油器促动控制阀
0091 Throttle Position Signal油门位置信号
0094 Fuel Pressure Sensor燃油压力国传感器
0100 Engine Oil Pressure Sensor发动机机油压力传感器
0110 Engine Coolant Temperature Sensor发动机冷却液温度传感器
0164 Injector Actuation Pressure喷油器促动压力
0168 System Voltage 系统电压
0172 Intake Manifold Air Temperature进气岐管空气温度
0175 Engine Oil Temperature Sensor发动机机油温度传感器
0190 Engine Speed Sensor发动机速度传感器
0253 Personality Module 个性模块
0261 Engine Timing Calibration发动机正时校验
0262 5V Sensor DC Power Supply5V传感器直流电源
0268 Check Programable Parameters检查可编程参数
0273 Turbo Outlet Pressure Sensor涡轮增压器出口压力传感器
0274 Atmospheric Pressure Sensor大气压力传感器
0286 Oil Lamp机油灯
0342 Secondary Engine Speed Sensor次级发动机速度传感器
0617 Air Inlet Heater Relay空气进气加热继电器
1627 Fuel Pump Relay燃油泵继电器Engine / Pump Control发动机/泵控制器(MID No. 105)CID Component元件
0091 Throttle Position Signal油门位置信号
0096 Fuel Level Sensor燃油油位传感器
0110 Engine Coolant Temperature Sensor发动机冷却液温度传感器
0167 Alternator发电机
0168 Voltage Of The Power Supply (Keyswitch) 钥匙门电压
0190 Speed Sensor速度传感器
0248 Cat Data LinkCAT数据线
0286 Signal For Low Engine Oil Pressure发动机机油压力低信号
0374 Swing Brake Solenoid回转制动电磁阀
0376 Travel Alarm 行走警报
0581 "Proportional Reducing Valve For The Powershift Pressure"动力换档比例减压阀
0586 Engine Speed Dial发动机速度盘式开关
0587 Feedback Sensor For The Governor Actuator调节器传动装置反馈信号
0590 Engine Controller发动机控制器
0598 Travel Speed Solenoid行走速度电磁阀
0600 Hydraulic Oil Temperature Sensor液压油温传感器
1161 Pump Delivery Pressure泵压
1162 Pump Delivery Pressure泵压
1524 "Proportional Solenoid Valve ForNegative Flow Control"负流量控制比例电磁阀1525Straight Travel Solenoid直线行走电磁阀1590"Proportional Solenoid Valve ForNegative Flow Control" 负流量控制比例电磁阀2002Action Alarm警报FMI故障描述
0 Data valid but above normal operationl range数据正确，但高于正常范围
1 Data valid but below normal operationl range数据正确，但低于正常范围
2 Data erratic,intermittent ,or incorrect数据不稳，断续或不正确
3 Voltage above normal or shorted high电压高于正常或突然高
4 Voltage below normal or shorted low电压低于正常或突然低
5 Current below normal or open circuit电流低于正常或开路
6 Current above normal or grounded circuit电流高于正常或短路
7 Mechanical system not responding properly机器系统没有正确反应
8 Abnormal frequency, pulse width, or period.异常频率、脉冲或周期
9 Abnormal update.异常更新
10 Abnormal rate of change.异常变化率
11 Failure mode not identifiable.故障模式不能确认
12 Bad device or component.坏的设备或元件
13 Out of calibration.超出校验范围
14-31 Reserved保留事件代码Event Codes事件代码Engine / Pump Control发动机/泵控制器Event Code Condition
017 Coolant Overheat冷却液高温
043 "Abnormal Battery Charge(Voltage To Power Supply Low)" 电压异常（电压低）
050 "Abnormal Battery Charge(Voltage To Power Supply High)" 电压异常（电压高）
059 Insufficient Level Of Coolant冷却液不足
095 Fuel Filter Is Clogged燃油滤芯堵塞
100 Engine Oil Pressure Is Low发动机机油压力低
119 Fuel Level Is Low燃油油位低
171 Engine Oil Level Is Low发动机机油油位低
179 "Abnormal Battery Charge(Charging Is Abnormal)" 电瓶充电异常
232 Water Separator Draining Demand油水分离器需排水
235 Hydraulic Oil Level Is Low液压油位低
236 Hydraulic Oil Filter Is Clogged液压油滤芯堵塞
237 Overload Warning过载警报
272 Air Filter Is Clogged空气滤芯堵塞
600 Hydraulic Oil Overheat液压油高温
862 Special Filter Is Clogged专用滤芯堵塞
863 Automatic Greasing Failure油脂自动注油失败Event Codes事件代码Engine Control发动机控制器Event CodeCondition
005 Fuel Filter Restriction Derate燃油滤芯堵塞减额
015 High Engine Coolant Temperature Derate冷却液高温减额
017 High Engine Coolant Temperature Warning冷却液高温警报
025 High Inlet Air Temperature Derate进气温度高减额
027 High Inlet Air Temperature Warning进气温度高警报
039 Low Engine Oil Pressure Derate机油压力低减额
096 High Fuel Pressure燃油压力高
100 Low Engine Oil Pressure Warning发动机机油压力低警报
190 Engine Overspeed Warning发动机超速警报
265 User Defined Shutdown用户自定义熄火挖掘机技术故障与师傅进行沟通交流，官方网站//www.wxfao.com修理直拨:0551-64493367 服务专线:13956953738
0001 Injector Solenoid 1st Cylinder1#缸喷油器电磁阀
0002 Injector Solenoid 2nd Cylinder2#缸喷油器电磁阀
0003 Injector Solenoid 3rd Cylinder3#缸喷油器电磁阀
0004 Injector Solenoid 4th Cylinder4#缸喷油器电磁阀
0005 Injector Solenoid 5th Cylinder5#缸喷油器电磁阀
0006 Injector Solenoid 6th Cylinder6#缸喷油器电磁阀
0041 8V DC Supply 8V直流电源
0042 Injection Actuation Control Valve喷油器促动控制阀
0091 Throttle Position Signal油门位置信号
0094 Fuel Pressure Sensor燃油压力国传感器
0100 Engine Oil Pressure Sensor发动机机油压力传感器
0110 Engine Coolant Temperature Sensor发动机冷却液温度传感器
0164 Injector Actuation Pressure喷油器促动压力
0168 System Voltage 系统电压
0172 Intake Manifold Air Temperature进气岐管空气温度
0175 Engine Oil Temperature Sensor发动机机油温度传感器
0190 Engine Speed Sensor发动机速度传感器
0253 Personality Module 个性模块
0261 Engine Timing Calibration发动机正时校验
0262 5V Sensor DC Power Supply5V传感器直流电源
0268 Check Programable Parameters检查可编程参数
0273 Turbo Outlet Pressure Sensor涡轮增压器出口压力传感器
0274 Atmospheric Pressure Sensor大气压力传感器
0286 Oil Lamp机油灯
0342 Secondary Engine Speed Sensor次级发动机速度传感器
0617 Air Inlet Heater Relay空气进气加热继电器
1627 Fuel Pump Relay燃油泵继电器Engine / Pump Control发动机/泵控制器(MID No. 105)CID Component元件
0091 Throttle Position Signal油门位置信号
0096 Fuel Level Sensor燃油油位传感器
0110 Engine Coolant Temperature Sensor发动机冷却液温度传感器
0167 Alternator发电机
0168 Voltage Of The Power Supply (Keyswitch) 钥匙门电压
0190 Speed Sensor速度传感器
0248 Cat Data LinkCAT数据线
0286 Signal For Low Engine Oil Pressure发动机机油压力低信号
0374 Swing Brake Solenoid回转制动电磁阀
0376 Travel Alarm 行走警报
0581 "Proportional Reducing Valve For The Powershift Pressure"动力换档比例减压阀
0586 Engine Speed Dial发动机速度盘式开关
0587 Feedback Sensor For The Governor Actuator调节器传动装置反馈信号
0590 Engine Controller发动机控制器
0598 Travel Speed Solenoid行走速度电磁阀
0600 Hydraulic Oil Temperature Sensor液压油温传感器
1161 Pump Delivery Pressure泵压
1162 Pump Delivery Pressure泵压
1524 "Proportional Solenoid Valve ForNegative Flow Control"负流量控制比例电磁阀1525Straight Travel Solenoid直线行走电磁阀1590"Proportional Solenoid Valve ForNegative Flow Control" 负流量控制比例电磁阀2002Action Alarm警报FMI故障描述
0 Data valid but above normal operationl range数据正确，但高于正常范围
1 Data valid but below normal operationl range数据正确，但低于正常范围
2 Data erratic,intermittent ,or incorrect数据不稳，断续或不正确
3 Voltage above normal or shorted high电压高于正常或突然高
4 Voltage below normal or shorted low电压低于正常或突然低
5 Current below normal or open circuit电流低于正常或开路
6 Current above normal or grounded circuit电流高于正常或短路
7 Mechanical system not responding properly机器系统没有正确反应
8 Abnormal frequency, pulse width, or period.异常频率、脉冲或周期
9 Abnormal update.异常更新
10 Abnormal rate of change.异常变化率
11 Failure mode not identifiable.故障模式不能确认
12 Bad device or component.坏的设备或元件
13 Out of calibration.超出校验范围
14-31 Reserved保留事件代码Event Codes事件代码Engine / Pump Control发动机/泵控制器Event Code Condition
017 Coolant Overheat冷却液高温
043 "Abnormal Battery Charge(Voltage To Power Supply Low)" 电压异常（电压低）
050 "Abnormal Battery Charge(Voltage To Power Supply High)" 电压异常（电压高）
059 Insufficient Level Of Coolant冷却液不足
095 Fuel Filter Is Clogged燃油滤芯堵塞
100 Engine Oil Pressure Is Low发动机机油压力低
119 Fuel Level Is Low燃油油位低
171 Engine Oil Level Is Low发动机机油油位低
179 "Abnormal Battery Charge(Charging Is Abnormal)" 电瓶充电异常
232 Water Separator Draining Demand油水分离器需排水
235 Hydraulic Oil Level Is Low液压油位低
236 Hydraulic Oil Filter Is Clogged液压油滤芯堵塞
237 Overload Warning过载警报
272 Air Filter Is Clogged空气滤芯堵塞
600 Hydraulic Oil Overheat液压油高温
862 Special Filter Is Clogged专用滤芯堵塞
863 Automatic Greasing Failure油脂自动注油失败Event Codes事件代码Engine Control发动机控制器Event CodeCondition
005 Fuel Filter Restriction Derate燃油滤芯堵塞减额
015 High Engine Coolant Temperature Derate冷却液高温减额
017 High Engine Coolant Temperature Warning冷却液高温警报
025 High Inlet Air Temperature Derate进气温度高减额
027 High Inlet Air Temperature Warning进气温度高警报
039 Low Engine Oil Pressure Derate机油压力低减额
096 High Fuel Pressure燃油压力高
100 Low Engine Oil Pressure Warning发动机机油压力低警报
190 Engine Overspeed Warning发动机超速警报
265 User Defined Shutdown用户自定义熄火挖掘机技术故障与师傅进行沟通交流，官方网站//www.wxfao.com修理直拨:0551-64493367 服务专线:13956953738
友情链接：
挖掘机维修
| 耐腐蚀泵
| 气液增压缸
| 衬氟设备
| 磨粉机
| 拨动开关
| 杭州包装设计
| uv灯
| 油液监测
| 房车锁
| 碳化硅厂家
| 聚氨酯泡棉
| 碳纤维拉挤
| 代理记帐
| 转轮除湿机
| 重庆防火门
| 龙岩钢闸门厂家
| 冻肉切丁机
| 滑雪场设计
| 直线模组
| 鹰嘴剪
| 氧化铁红
| 防爆电动滚筒
| 四川热轧钢板
| 全自动点胶机
| 水上滑梯厂
| 管道离心泵
| 广东护栏厂家
| 涡轮流量计厂
| 电伴热
| 洁净工作台
| 高低温试验箱
| 油液在线监测
| iso认证咨询
扫一扫二维码 微信咨询